燃氣發電機組排氣系統溫度較高，其燃料又易燃易爆，隱患較大，稍不注意，就有可能釀成災禍。那么燃氣發電機組機房以及設置的要求是怎樣的呢？

The temperature of the exhaust system of gas generator set is high, and the fuel is flammable and explosive, with a large hidden danger. If you do not pay attention, it may cause disasters. What are the requirements for the gas turbine generator room and its settings?

機房要求

Machine room requirements

燃氣發電機機房一般采用敞開式或半敞開式，應采用不發生火花的地面，地面應平整并易于清掃。

The gas generator room is generally open or semi open, and the ground without spark shall be used. The ground shall be flat and easy to clean.

如采用封閉式機房，應按相關規范中防爆要求設計，須是單層建筑，門窗一律外開，設置大流量排風裝置，防止可燃氣體積聚等。

If a closed machine room is used, it should be designed according to the explosion-proof requirements in the relevant specifications. It must be a single storey building, with doors and windows all open, and a large flow exhaust device should be set to prevent the accumulation of flammable gas.

機房與操作間應隔開，不得直接連通，觀察窗口應用雙層玻璃，且有鋼絲網防護。

The machine room and the operation room shall be separated from each other and shall not be directly connected. The observation window shall be double glass and protected by steel wire mesh.

機房應設有避雷裝置。

The machine room shall be equipped with lightning arrester.

燃氣發電機組運行現場不得有明火，須有明顯的“嚴禁煙火”等警示標志。

There shall be no open fire on the operation site of gas generator unit, and there must be obvious warning signs such as "No Smoking".

配備充足的滅火器材。

Sufficient fire fighting equipment shall be provided.

發動機排氣系統的廢氣中，混有可燃氣體，要設計并安裝由發動機引向室外的排氣管系，排氣管系應連接可靠。

The exhaust gas of the engine exhaust system is mixed with combustible gas, so the exhaust pipe system leading from the engine to the outside shall be designed and installed, and the exhaust pipe system shall be reliably connected.

設備要求

Equipment requirements

燃氣發電機房內電氣設施應為防爆型，進行電氣維修時，須切斷電源。

The electrical facilities in the gas generator room shall be explosion-proof, and the power supply must be cut off during electrical maintenance.

在燃氣管道進機房處，應設置緊急閥門，以備廠房內發生緊急情況時，可迅速切斷氣源，此閥門應離操作間較近。

An emergency valve shall be set at the place where the gas pipeline enters the machine room, so that the gas source can be cut off quickly in case of emergency in the plant. The valve shall be close to the operation room.

燃氣發電機房內要安置燃氣濃度報警器，在機房對角處安兩個，當環境濃度在爆炸和中毒濃度范圍以內時，須強制通風，降低濃度后方可啟動機組。

The gas concentration alarm shall be installed in the gas generator room. Two gas concentration alarms shall be installed at the opposite corners of the machine room. When the environmental concentration is within the range of explosion and poisoning concentration, forced ventilation must be carried out, and the unit can be started only after the concentration is reduced.

在機房內使用燃氣發動機，用戶除了要遵守相關的安全規定外，還要根據具體情況，制定安全操作規程，并嚴格遵守。更多相關內容就來我們網站http://www.cxxrdz.com咨詢吧！

When using gas engines in the machine room, users should not only abide by the relevant safety regulations, but also formulate and strictly abide by the safety operation rules according to the specific situation. More relevant content will come to our website http://www.cxxrdz.com Consult!