沼氣發電具有創效、節能、安全和環保等特點，而且在發達國家已受到廣泛重視和積極推廣，我們國家也是的推廣。那么沼氣發電機究竟是利用了何種原理呢？

Biogas power generation has the characteristics of efficiency creation, energy conservation, safety and environmental protection, and has been widely valued and actively promoted in developed countries, and our country is also a key promotion. So what is the principle of biogas generator?

它是利用工業、農業或城鎮生活中的大量有機廢棄物，經厭氧發酵處理產生的沼氣，驅動沼氣發電機發電，并可充分將發電機組的余熱用于沼氣生產。沼氣發電熱電聯產項目的熱效率，視發電設備的不同而有較大的區別，如使用燃氣內燃機，其熱效率為70%~75%之間，而如使用燃氣透平和余熱鍋爐，在補燃的情況下，熱效率可以達到90%以上。

It uses a large amount of organic wastes in industry, agriculture or urban life, and the biogas produced by anaerobic fermentation to drive the biogas generator to generate electricity, and can fully use the waste heat of the generator set for biogas production. The thermal efficiency of the biogas power cogeneration project varies greatly depending on the power generation equipment. For example, if the gas internal combustion engine is used, its thermal efficiency is between 70% and 75%, while if the gas turbine and waste heat boiler are used, the thermal efficiency can reach more than 90% under the condition of supplementary combustion.

另外，沼氣發電機發電技術本身提供的是清潔能源，不僅解決了沼氣工程中的環境問題、消耗了大量廢棄物、保護了環境、減少了溫室氣體的排放，而且變廢為寶，產生了大量的熱能和電能，符合能源再循環利用的環保理念，同時也帶來巨大的經濟效益。

In addition, biogas generator power generation technology itself provides clean energy, which not only solves the environmental problems in biogas projects, consumes a lot of waste, protects the environment, reduces greenhouse gas emissions, but also turns waste into treasure, generating a lot of heat and electricity, which is in line with the environmental protection concept of energy recycling, but also brings huge economic benefits.

使用方法

usage method

1、起動：關閉沼氣閥，按瓦斯機的起動方法，用瓦斯起動操作方法與未改裝前一樣。

1. Start: close the biogas valve and start the gas machine according to the starting method. The operation method of starting with gas is the same as that before refitting.

2、起動后的操作：起動后帶上負荷，將瓦斯機油門放在合適的位置（一般放在中間偏低一點位置），待發動機運轉正常后，慢慢地打開沼氣閥門輸入沼氣。通入沼氣后，在調速器作用下供油量自動減少，發動機轉速穩定。若沼氣輸入量過多，發動機會出現瞬間供油中斷現象，產生斷續的工作聲。

2. Operation after starting: after starting, put the load on, put the gas engine throttle at the appropriate position (generally at the lower position in the middle), and slowly open the biogas valve to input biogas after the engine operates normally. After the biogas is introduced, the fuel supply will be automatically reduced under the action of the governor, and the engine speed will be stable. If the biogas input is too much, the engine will have an instantaneous oil supply interruption, resulting in intermittent working sound.

遇到這種情況，應隨時即將沼氣閥略微關小，直到正常運轉為止。在運轉過程中，調整轉速的方法與改裝前用瓦斯工作時一樣，通過改變油門手柄位置來進行。隨著雙燃料發動機轉速或負荷大小的改變，也要相應的開大或關小沼氣閥門，以保證雙燃料發動機正常運轉和較好的節油效果。當沼氣—瓦斯機冷卻水溫較低已及小負荷運行時，節油效果差。

In this case, the biogas valve shall be slightly turned down at any time until it operates normally. In the process of operation, the method of adjusting the speed is the same as that of working with gas before refitting, by changing the position of the throttle handle. With the change of the speed or load of the dual fuel engine, the biogas valve should be opened or closed accordingly to ensure the normal operation of the dual fuel engine and better fuel saving effect. When the cooling water temperature of the biogas gas machine is low and the low load operation, the oil saving effect is poor.

沼氣發電機組利用了什么原理工作的？以上就是為您講解的內容了，提醒您在使用之前要多去了解相關操作的安全事項，這點很重要，更多事項就來我們網站http://www.cxxrdz.com咨詢吧。

What principle does the biogas generator unit work on? The above is the content explained for you. It is important to know more about the safety matters of relevant operations before using it. For more matters, please come to our website http://www.cxxrdz.com Consult.