不論高濃度和低濃度的燃?xì)獍l(fā)電機組，由于特殊性就要注意發電機組的檢測和維護，此外瓦斯發電機組的維護應靈活控制啟動時間，下面來講解下維修檢查工作怎么做。

Regardless of the high concentration and low concentration of gas generator units, due to the particularity of natural gas, attention should be paid to the detection and maintenance of generator units. In addition, the maintenance of gas generator units should flexibly control the starting time. Here is how to do the maintenance and inspection.

瓦斯發電機組A類維修檢查

Class A maintenance and inspection of gas generator set

檢查發電機組的日常工作報告，并根據日常工作報告安排維護和必要的調整。

Check the daily work report of the generator set, and arrange maintenance and necessary adjustment according to the daily work report.

檢查發電機組的平面和冷卻液液位，主要是區分油尺的高度標記和位置標記。冷卻后，須檢查冷卻平面。

Check the plane and coolant level of the generator set, mainly to distinguish the height mark and position mark of the oil dipstick. After cooling, check the cooling surface.

檢查發電機組是否損壞，皮帶是否松動或磨損。如果皮帶松動或打滑，應及時進行調整或更換。

Check whether the generator set is damaged and whether the belt is loose or worn. If the belt is loose or slipping, it shall be adjusted or replaced in time.

機組正常啟動后，檢查機油壓力是否正常，功率是否充足，冷卻水和機油溫度是否正常以及燃料，冷卻劑和潤滑油是否泄漏。

After the unit starts normally, check whether the oil pressure is normal, whether the power is sufficient, whether the temperature of cooling water and oil is normal, and whether the fuel, coolant and lubricating oil leak.

瓦斯發電機組B級檢修

Level B maintenance of gas generator set

更換發電機組的機油。更換時間為250小時或1個月。換油標準不得超過油尺上的高標記。

Change the engine oil of the generator set. The replacement time is 250 hours or 1 month. The oil change standard shall not exceed the high mark on the oil dipstick.

更換發電機組的機油濾清器。在安裝新的機油濾清器之前，好在密封件上涂抹一層機油。請勿過度擰緊機油濾清器，否則會導致機油泄漏。

Replace the oil filter of the generator set. Before installing a new oil filter, coat the seal with oil. Do not overtighten the oil filter, or oil leakage may occur.

更換機油濾清器濾芯。更換濾芯時，須排出發電機組中的空氣。

Replace the oil filter element. When replacing the filter element, the air in the generator set must be exhausted.

發電機組的空氣過濾器進行清潔或更換。

Clean or replace the air filter of the generator set.

以上是瓦斯發電機組維修檢查分A、B類這一問題的相關解答內容了，您對此有什么不理解的地方可以隨時來我們網站http://www.cxxrdz.com留言咨詢。

The above is the answer to the question of gas generator unit maintenance and inspection divided into A and B categories. If you have any questions about this, you can come to our website at any time http://www.cxxrdz.com Leave a message for consultation.